A method of cleaning lubricating oil on line was investigated using a fine bypass particulate filter followed by an infra red heater. Two bypass filter sizes of 6 and 1 micron were investigated, both filter sizes were effective but the one micron filter had the greatest benefit. This was tested on two nominally identical EURO 2 emissions compliance single decker buses, fitted with Cummins 6 cylinder 8.3 litre turbocharged intercooled engines and coded as Bus 4063 and 4070. These vehicles had emissions characteristics that were significantly different, in spite of their similar age and total mileage. Bus 4063 showed an apparent deterioration on emissions with time while Bus 4070 showed a stabilised trend on emissions with time for their baseline tests without the recycler fitted. Comparison was made with the emissions on the same vehicles and engines with and without the on-line bypass oil recycler. Engine exhaust emissions were measured about every 2000 miles. All tests started with an oil drain and fresh lubricating oil. The two buses were tested in a different sequence, Bus 4063 with the recycler fitted and then removed later in the test after an oil change and Bus 4070 with no recycler fitted at first and then fitted after 29,000 miles with no oil change. The Bus 4070 was also the one with the finer bypass filter. The test mileage was 45,000 miles for Bus 4063 and 48,000 miles for Bus 4070. The air/fuel ratio was worked out by the exhaust gas analysis. The correlation between air/fuel ratio and emission parameters was determined. The results showed that the on line oil recycler cleaning system reduced the rate of increase of the NOx from 5% to 1.6% for Bus 4063 and from 4.1% to 0% for Bus 4070 per 10,000 miles. Hydrocarbon emissions increased 30 ppm per 10,000 miles with the recycler removed compared to a stabilised level with the recycler fitted for Bus 4063. There was a small decrease in hydrocarbon emissions after fitting the recycler for Bus 4070. The particulate emissions were reduced by 35% for Bus 4063 and 24% for Bus 4070 on average. The reductions on total particulate mass were due to reductions on particulate carbon and lube oil VOF emissions. The black smoke was reduced by 56% for Bus 4063 in terms of rate of increase and 40% for Bus 4070 in terms of average values
Effects of an on Line Bypass Oil Recycler on Emissions with Oil Age for a Bus Using in Service Testing
Sae Technical Papers
SAE International Fall Fuels & Lubricants Meeting & Exhibition ; 2001
2001-09-24
Conference paper
English
Effects of an line bypass oil recycler on emissions with oil age for a bus using on service testing
Automotive engineering | 2001
|British Library Conference Proceedings | 2001
|Automotive engineering | 2001
|SAE Technical Papers | 2001
|