The Orbital Combustion Process (OCP) has been successfully implemented on automotive and marine engines. Large marine outboards are in production using this technology for emissions control and a limited release of vehicles is underway. ULEV emissions have also been measured in independent laboratories on the automotive engine.The fuel injection system has been adapted to 50cc scooters. Although the same basic injector has been retained, the remainder of the system has been optimized for the different cost, engine size and emission constraints applicable to this market. The system utilizes a crankcase pressure actuated positive displacement metering system with a much simplified control system compared with marine and automotive systems. The basic scooter system has been previously described in SAE 9416871.The combustion process is substantially changed from that used on the larger automotive engines due to the smaller bore size and higher engine operating speed.Optimization of the combustion chamber and injection system for both maximum power and minimum emissions is discussed, including modifications to the cylinder head and piston design, and injector spray requirements. Typical air to fuel ratios and parameter timings are also presented.The resultant misfire free scooter engine demonstrates similar power, reduced fuel consumption and compliance with emission regulations at low incremental cost to the vehicle manufacturer.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Exhaust Emissions Sensitivities with Direct Injection on a 50cc Scooter


    Weitere Titelangaben:

    Sae Technical Papers


    Beteiligte:
    Finucci, Carmine (Autor:in) / Bell, Greg (Autor:in)

    Kongress:

    International Congress & Exposition ; 1997



    Erscheinungsdatum :

    1997-02-24




    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch




    Exhaust emissions sensitivities with direct injection on a 50cc scooter

    Bell,G. / Finucci,C. / Meteor,US | Kraftfahrwesen | 1997


    Development of Electronic Throttle Actuation for a 50cc 2-Stroke Scooter Application

    Smither, B. / Demesse, E. / Farmer, G. et al. | SAE Technical Papers | 2011


    A 50cc two-stroke direct injection compression ignition engine fuelled by dimethylether

    Hansen,K.R. / Nielsen,C.S. / Sorenson,S.C. et al. | Kraftfahrwesen | 2008


    Limited emissions and nanoparticles of a scooter with 2-stroke direct injection ( TSDI )

    Czerwinski,J. / Comte,P. / Univ.Biel-Bienne,CH | Kraftfahrwesen | 2003