This paper describes the development of a spark ignition engine operating in a stratified-EGR mode at part load. The concept is to reduce the pumping loss with high levels of EGR while maintaining stable combustion via charge stratification. Since the engine operates stoichiometrically, the ability to control NOx emissions by the three-way catalyst is retained. The configuration of introducing the stoichiometric fresh mixture to the center portion of the combustion chamber with the EGR gas on the two sides is visualized in a transparent engine using planar laser-induced fluorescence (PLIF) and Mie scattering. Visualization results showed that the stratification between air/fuel mixture and EGR gas was relatively well established during the intake stroke. There was, however, significant mixing in the late part of the compression stroke. Performance comparison (at the same fuel flow and at MBT spark timing) between the engine operating at part load with the homogeneous mixture and with the stratified mixture demonstrated that the stratified mode had greatly improved specific fuel consumption and had provided stable combustion at high EGR dilution. A simple combustion model based on a local EGR level which is an empirical function of the mass fraction burned was used to explain the data. The observed pressure trace and heat release rate could be reproduced well by the model.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Design and Demonstration of a Spark Ignition Engine Operating in a Stratified-EGR Mode


    Weitere Titelangaben:

    Sae Technical Papers


    Beteiligte:
    Han, Sangmyeong (Autor:in) / Cheng, Wai K. (Autor:in)

    Kongress:

    International Congress & Exposition ; 1998



    Erscheinungsdatum :

    1998-02-23




    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch




    Design and demostration of a spark ignition engine operating in a stratified-EGR mode

    Han,S. / Cheng,W.K. / Daewoo Motor,KR et al. | Kraftfahrwesen | 1998


    Combustion characteristics of a direct-injection stratified charge spark ignition engine

    Itoh,T. / Iiyama,A. / Muranaka,S. et al. | Kraftfahrwesen | 1998


    Stratified Charge Operation of Spark Ignition Engines

    Bascunana, Jose L. / Conta, Lewis D. / Durbetaki, Pandeli | SAE Technical Papers | 1961