The impact of oil-derived catalyst poisons on the FTP performance of a LEV configured with two different catalyst systems was studied. One of these catalyst configurations was composed of a single underfloor Pt-Rh converter while the other was composed of a Pd lightoff catalyst close-coupled to the exhaust manifold and a Pt-Rh catalyst located underfloor. Both configurations were aged to approximately 100,000 miles on vehicles and were then evaluated for FTP emissions performance. The oil-derived poisons were then selectively removed using a wet chemical method, and following this the catalyst systems were again evaluated for FTP performance.In the lightoff and underfloor catalyst system, removal of the oil-derived poisons improved the FTP Cycle 1 and Bag 1 HC tailpipe emissions significantly. Although Bag 2 and 3 emissions are also improved, the absolute g/mi improvement in this latter case contributes very little to the overall FTP emissions. These results are consistent with earlier laboratory studies of this type of catalyst system which predicted that oil-derived poisons selectively impact the front-most catalyst element and should consequently impact HC and CO lightoff performance. The oil-derived poisons were also found to significantly impact the HC, CO and NOx lightoff performance in the underfloor-only catalyst system. The relatively large impact observed with this catalyst system may be attributable to the optimization of the vehicle for LEV emission standards, resulting in an increased sensitivity of the system to deterioration effects previously considered minor or insignificant in older generation Tier 0 or Tier 1 emission systems.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Impact of Oil-Derived Catalyst Poisons on FTP Performance of LEV Catalyst Systems


    Weitere Titelangaben:

    Sae Technical Papers


    Beteiligte:
    DiMaggio, C. L. (Autor:in) / Frank, D. A. (Autor:in) / Beck, D. D. (Autor:in) / Monroe, D. R. (Autor:in) / Sommers, J. W. (Autor:in)

    Kongress:

    International Fuels & Lubricants Meeting & Exposition ; 1997



    Erscheinungsdatum :

    01.10.1997




    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch




    Impact of Oil-Derived Catalyst Poisons on FTP Performance of LEV Catalyst Systems

    Beck, D. D. / Sommers, J. W. / DiMaggio, C. L. et al. | British Library Conference Proceedings | 1997


    Impact of oil-derived catalyst poisons on FTP performance of LEV catalyst systems

    Beck,D.D. / Sommers,J.W. / DiMaggio,C.L. et al. | Kraftfahrwesen | 1997


    The effects of oil-derived poisons on three-way catalyst performance

    Lafyatis,D.S. / Petrow,R. / Bennett,C. et al. | Kraftfahrwesen | 2002


    The Effects of Oil-Derived Poisons on Three-Way Catalyst Performance

    Bennett, Chris / Lafyatis, David S. / Petrow, Rick | SAE Technical Papers | 2002


    Three-way Catalyst Deactivation Associated With Oil-Derived Poisons

    Kubsh, J. / Deutsche Gesellschaft fur Materialkunde | British Library Conference Proceedings | 2002