A 2.0L twin-scroll turbocharged SIDI engine was used to evaluate low-pressure loop water-cooled external EGR at operating conditions between 1000 rpm 75 Nm and 3000 rpm 250 Nm. The engine compression ratio was increased from 9.3 to 10.9. The maximum fuel consumption reduction potential, the boost pressure requirements, and the optimized external EGR calibration were determined. Combination of higher compression ratio and external EGR achieved 5-7% better fuel economy over mid-load region when using the twin-scroll turbocharger. A similar (4-6%) better fuel economy was observed over much of the higher-load region, including peak torque condition at 1000rpm, when the required boost pressure was provided by an externally-driven auxiliary boost system (not connected to the engine). The power consumption of auxiliary boost system (supercharger loss) was estimated and considered in fuel economy assessment. The fuel consumption reduction mechanisms of EGR were also analyzed. This study shows that reduced pumping loss attributed to about 0.5% fuel consumption reduction per 10% EGR, heat loss reduction and better mixture properties offered above 2% fuel consumption reduction per 10% EGR. In addition, combustion phasing improvement by adding EGR played the main role to reduce the fuel consumption at knock-limited conditions, up to 4% at low speeds and high loads.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Fuel Consumption Evaluation of Cooled External EGR for a Downsized Boosted SIDI DICP Engine


    Weitere Titelangaben:

    Sae Technical Papers


    Beteiligte:
    Cleary, David (Autor:in) / Liu, Zhimin (Autor:in)

    Kongress:

    SAE 2014 World Congress & Exhibition ; 2014



    Erscheinungsdatum :

    01.04.2014




    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch




    Fuel Consumption Evaluation of Cooled External EGR for a Downsized Boosted SIDI DICP Engine

    Liu, Z. / Cleary, D. / Society of Automotive Engineers | British Library Conference Proceedings | 2014


    Downsized boosted engine benchmarking and results

    Stuhldreher,M. / Schenk,C. / Brakora,J. et al. | Kraftfahrwesen | 2015


    Downsized Boosted Engine Benchmarking and Results

    Moskalik, Andrew / Schenk, Charles / Hawkins, David et al. | SAE Technical Papers | 2015


    Downsized Boosted Engine Benchmarking and Results

    Stuhldreher, Mark / Schenk, Charles / Brakora, Jessica et al. | British Library Conference Proceedings | 2015


    Split-Injection in a Downsized Ethanol SIDI Engine Aiming to Mitigate Pre-Ignition

    Malaquias, Augusto C. T. / Filho, Fernando R. / Baeta, José G. C. et al. | SAE Technical Papers | 2017