Soot is the largest component of contaminants found in the diesel engine lubricating oil. The soot enters lubricating oil mainly through thermophoretic deposition on the cylinder wall. Although the mechanism is still not fully understood, it is generally accepted that soot particles promote engine wear, reducing engine component service life, fuel efficiency and performance. This problem will be further exacerbated when more and more diesel engines use EGR to reduce NOx emissions and when lubricating oil consumption is drastically reduced to control particulate emissions.In this study, lubricating oil samples were taken from 7 different operating diesel engines. The size distribution and concentration of the diesel soot particles in the lubricants were investigated by methods of photosedimentation and quantitative spectrophotometry. The size distributions were compared to those of soot particles in the exhaust. It was found that the mass weighted median diameter of soot particles in the lubricating oil varies from 0.12 to 0.27 μm, and the geometrical standard deviation from 2.4 to 4.0, largely dependent on the type of the engines. The soot size distribution in the oil is in general similar to that in the exhaust. For a single cylinder diesel engine, soot particles were found entering the lubricating oil at a rate of approximately 4% of the total dry exhaust particulate mass emission rate, which in turn is about 0.1% of the fuel mass consumed.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Size Distribution of Diesel Soot in the Lubricating Oil


    Weitere Titelangaben:

    Sae Technical Papers


    Beteiligte:

    Kongress:

    International Fuels & Lubricants Meeting & Exposition ; 1991



    Erscheinungsdatum :

    1991-10-01




    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch




    Size distribution of diesel soot in the lubricating oil

    Sun,R. / Kittelson,D.B. / Blackshear,P.L. et al. | Kraftfahrwesen | 1991


    Soot filtration for Diesel Engine Lubricating Oil

    Guillon, Christophe / GUERBE, Laurent | SAE Technical Papers | 2010


    Soot & Acid Control in Diesel Lubricating Systems

    Birch, Brent L. | SAE Technical Papers | 2004


    Soot filtration for diesel engine lubricating oil

    Guillon,C. / Guerbe,L. / Sogefi,FR | Kraftfahrwesen | 2010


    Measurement of Soot in Diesel Engine Lubricating Oil

    Desjardins, John B. / Seifert, William W. | SAE Technical Papers | 1995