It is well known that lean operation of homogeneous- charge spark-ignited engines is effective in increasing thermal efficiency and reducing exhaust emissions. In particular, the lower combustion temperatures provided by a lean air-fuel mixture result in a significant reduction in NOx emissions. Lean operation is normally restricted, however, by the “lean-limit” of combustion, as measured by the air-fuel ratio above which ignition is impossible, or combustion is incomplete. In order to extend the lean limit of operation a new “partially-stratified charge” combustion concept has been developed. This technique relies on the fact that a stronger initial flame kernel produced following the spark event should also be effective in igniting a very lean mixture which may not otherwise ignite, or which may result in incomplete combustion. An innovative spark-plug insert design, in which a small portion of “pilot fuel” is injected directly near the spark plug electrodes, provides a small pocket of relatively rich mixture that ignites more readily than the main, very lean, combustion charge. This has then been used to extend the lean-limit of operation of natural-gas fuelled spark-ignition engines, resulting in reduced brake specific fuel consumption and significantly lower levels of NOx emissions. This process has also been shown to be effective in increasing the stability of combustion, thereby reducing cyclic variations in cylinder pressure. Recent data obtained using this concept in a single-cylinder research engine are reported in this paper. In addition, some initial studies of the partially stratified-charge mixing process are also described.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    The Ultra Lean Burn Partially Stratified Charge Natural Gas Engine


    Weitere Titelangaben:

    Sae Technical Papers


    Beteiligte:
    Mezo, A. (Autor:in) / Davy, M. (Autor:in) / Evans, R.L. (Autor:in)

    Kongress:

    9th International Conference on Engines and Vehicles ; 2009



    Erscheinungsdatum :

    13.09.2009




    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch




    Lean burn combustion influence on stratified charge ethanol direct injection engine

    Franco, Rafael Lara / Junior, Carlos Alberto Gomes / Da Costa, Roberto Berlini Rodrigues et al. | British Library Conference Proceedings | 2016


    Lean Burn Combustion Influence on Stratified Charge Ethanol Direct Injection Engine

    Gomes Júnior, Carlos Alberto / Rodrigues Filho, Fernando Antonio / Franco, Rafael Lara et al. | SAE Technical Papers | 2016


    The time history of the mixture formation process in a lean burn stratified-charge engine

    Berckmueller,M. / Tait,N.P. / Greenhalgh,D.A. et al. | Kraftfahrwesen | 1996


    The Time History of the Mixture Formation Process in a Lean Burn Stratified-Charge Engine

    Greenhalgh, Douglas A. / Berckmüller, Martin / Tait, Nigel P. | SAE Technical Papers | 1996


    Development of Four-valve, Center Spark-plug MVV Engine with Barrel-Stratified Charge Lean-burn Concept

    Kume, T. / Iwamoto, Y. / Hirako, O. et al. | British Library Conference Proceedings | 1993