Knock-induced pressure waves in the combustion chambers of spark-ignited engines cause the engine block to vibrate at the same frequencies. These vibrations have different amplitudes at different locations on the engine block. This paper describes a project to find a location on the engine block where the amplitudes of the knock-induced vibrations are high enough to use in a knock control system. To find this location, six piezoelectric knock sensors were located on suitable regions of the engine block. Data were collected from the sensors at both knocking and non-knocking conditions using a high speed data acquisition system. After the data were transformed into the frequency domain, comparison of the knocking and non-knocking condition data indicated the frequencies and amplitudes of the knock-induced engine block vibrations. The location where knock-induced vibrations were transferred with the greatest amplitude was determined. This location was confirmed at various speeds and air/fuel ratios. The test results indicated that the best location for the knock sensor was the lower-left side of the engine block between the third and fourth cylinders. A horizontally-mounted knock sensor provided a Signal-to-Noise ratio of 3.6.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Determination of Knock Sensor Location on a Heavy-Duty Natural Gas Engine


    Weitere Titelangaben:

    Sae Technical Papers


    Beteiligte:
    Van Gerpen, Jon (Autor:in) / Soylu, Seref (Autor:in)

    Kongress:

    International Spring Fuels & Lubricants Meeting & Exposition ; 1997



    Erscheinungsdatum :

    01.05.1997




    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch




    Determination of knock sensor location on a heavy-duty natural gas engine

    Soylu,S. / Van Gerpen,J. / Iowa State Univ.,Ames,US | Kraftfahrwesen | 1997


    3-dimensional Simulation of Knock in a Heavy-Duty LPG Engine

    Choi, Hoimyung / Lee, Joungwon / Min, Kyoungdoug et al. | SAE Technical Papers | 2002


    3-dimensional simulation of knock in a heavy-duty LPG engine

    Choi,H. / Hwang,S. / Lee,J. et al. | Kraftfahrwesen | 2002


    Surge Detection Using Knock Sensors in a Heavy Duty Diesel Engine

    Puttige, Anjan Rao / Hamberg, Robin / Linschoten, Paul et al. | British Library Conference Proceedings | 2017


    Engine Knock Control Via Optimization of Sensor Location

    Forbes, James W. / Carlstrom, Kevin R. / Graessley, William J. | SAE Technical Papers | 1995