Airframe icing caused by supercooled large droplets (SLD) has been identified as a severe hazard in aviation. This study presents an investigation of impact of a supercooled drop onto superhydrophobic and partially wettable substrates. Drop impact, spreading and rebound were observed using a high-speed video system. The maximum spreading diameter of an impacting drop on partially wettable surfaces was measured. The temperature effect on this parameter was only minor for a wide range of the drop and substrate temperatures. However solidification hindered receding when both the drop and substrate temperatures were below 0°C. The minimum receding diameter and the speed of ice accretion on the substrate were measured for various wall and drop temperatures. The two parameters increased almost linearly with the decrease of the wall temperature, but eventually leveled off beyond a certain substrate temperature. The speed of ice accretion on the substrate was significantly higher than the growth rate of free ice dendrites at a certain supercooling. These disparities are attributed to formation of multiple initial nucleation sites and the liquid flow. These experimental results suggest that the superhydrophobic coating cannot prevent in-flight icing, but the total rebound of supercooled drops on protected surfaces, which are heated above the freezing point, would possibly reduce the energy consumption for ice protection.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Impact of Supercooled Liquid Drops onto Cold Solid Substrates


    Weitere Titelangaben:

    Sae Technical Papers


    Beteiligte:
    Tropea, Cameron (Autor:in) / Li, Hai (Autor:in) / Roisman, Ilia (Autor:in)

    Kongress:

    SAE 2015 International Conference on Icing of Aircraft, Engines, and Structures ; 2015



    Erscheinungsdatum :

    2015-06-15




    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch







    Five Ways to Produce Supercooled Drizzle Drops

    McCann, D. W. / American Meteorological Society | British Library Conference Proceedings | 1997


    Measurements of Aircraft Icing Environments Which Include Supercooled Large Drops

    Cober, S. G. / Isaac, G. A. / Korolev, A. V. et al. | British Library Conference Proceedings | 1999