A large scale model representative of a low-noise, high bypass ratio turbofan engine was tested for acoustics and performance in the NASA Lewis 9- by 15-Foot Low-Speed Wind Tunnel. This test was part of NASA's continuing Advanced Subsonic Technology Noise Reduction Program. The low tip speed fan, nacelle, and an un-powered core passage (with core inlet guide vanes) were simulated. The fan blades and hub are mounted on a rotating thrust and torque balance. The nacelle, bypass duct stators, and core passage are attached to a six component force balance. The two balance forces, when corrected for internal pressure tares, measure the total thrust-minus-drag of the engine simulator. Corrected for scaling and other effects, it is basically the same force that the engine supports would feel, operating at similar conditions. A control volume is shown and discussed, identifying the various force components of the engine simulator thrust and definitions of net thrust. Several wind tunnel runs with nearly the same hardware installed are compared, to identify the repeatability of the measured thrust-minus-drag. Other wind tunnel runs, with hardware changes that affected fan performance, are compared to the baseline configuration, and the thrust and torque effects are shown. Finally, a thrust comparison between the force balance and nozzle gross thrust methods is shown, and both yield very similar results.


    Zugriff

    Zugriff über TIB

    Verfügbarkeit in meiner Bibliothek prüfen


    Exportieren, teilen und zitieren



    Titel :

    Model Engine Performance Measurement From Force Balance Instrumentation


    Beteiligte:
    R. J. Jeracki (Autor:in)

    Erscheinungsdatum :

    1998


    Format / Umfang :

    30 pages


    Medientyp :

    Report


    Format :

    Keine Angabe


    Sprache :

    Englisch






    Road Transducer - Objective Brake Balance Measurement Without Vehicle Instrumentation

    Wolanin, Michael J. / Baptist, Thomas A. | SAE Technical Papers | 1987


    Calibrating Large Capacity Aerodynamic Force Balance Instrumentation Using Response Surface Methods

    Simpson, James / Landman, Drew / Giroux, Rupert et al. | AIAA | 2005


    Road Transducer - Objective Brake Balance Measurement Without Vehicle Instrumentation

    Wolanin,M.J. / Baptist,T.A. / General Motors,US | Kraftfahrwesen | 1987