Abstract Compact micronewton thrusters can provide attitude control for small satellites to increase mission duration and enable constellation flying. Micronewton thrust control can also enhance missions that require precision pointing such as space telescopes, laser interferometers, and laser communication relays. Film-Evaporating MEMS Tunable Array (FEMTA) is a novel micropropulsion device that generates thrust by heating a micron-scale water capillary to induce controlled film-evaporation. Thrust stand tests under high vacuum have shown that FEMTA can produce controllable thrust of 150μN at 70s specific impulse using 0.65W of electrical power and ultra-pure deionized water as propellant. An undesired quiescent propellant loss rate is inherent to the current FEMTA design which limits its life span and reliability. To derive mitigations to this issue, the behavior of the fluid interface within the FEMTA micronozzle was characterized through direct experimentation. A test-bed FEMTA design was created which enabled direct observation of the liquid within the micronozzles and precise control over critical nozzle dimensions. These test-bed devices were used to measure contact angle, Laplace pressure, and total quiescent propellant loss rates for multiple nozzle configurations. Finally, a next generation FEMTA design was derived from the findings of these studies and its propulsive performance was measured under high vacuum on a micronewton thrust stand. Microfabrication was performed at Purdue’s Birck Nanotechnology Center and vacuum testing was completed at Purdue’s High Vacuum Lab.

    Highlights Film-evaporating water microcapillaries can serve as low power and mass thrusters. Micrometer water capillaries have acceptable evaporation rates for spaceflight. Plasma etched silicon capillary tubes produce lower than expected Laplace pressures.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Characterization of film-evaporating microcapillaries for water-based microthrusters


    Beteiligte:
    Pugia, Steven (Autor:in) / Cofer, Anthony (Autor:in) / Alexeenko, Alina (Autor:in)

    Erschienen in:

    Acta Astronautica ; 196 ; 442-458


    Erscheinungsdatum :

    2020-09-08


    Format / Umfang :

    17 pages




    Medientyp :

    Aufsatz (Zeitschrift)


    Format :

    Elektronische Ressource


    Sprache :

    Englisch






    Subliming Solid Microthrusters

    Online Contents | 1998


    Solid electrolyte-based microthrusters

    WEST WILLIAM C | Europäisches Patentamt | 2019

    Freier Zugriff

    Indium Field Emission Microthrusters

    Ruedenauer, F. G. / Fehringer, M. / Steiger, W. | British Library Conference Proceedings | 1997