Computer simulations, initial flight tests on a German Army CH-53G with "manual" pitch links and full-scale wind tunnel tests of a UH-60A rotor were conducted in order to investigate the capabilities of In-Flight Tuning to (a) reduce RT&B check flight time and (b) improve the 1/rev vibration level compared to what is achievable by today's RT&B process. It was demonstrated that active pitch links were able to compensate considerable inherent or simulated bladeto- blade dissimilarities. Moreover, the algorithms used were shown to be convergent and stable. Based on the results presented in this paper the following conclusions can be drawn: 1. The proposed architecture of an In-Flight Tuning System which solely uses adjustable pitch links is feasible to compensate unbalances resulting from mass and/or aerodynamic/geometric dissimilarities between the different blades; 2. With in-flight adjustable pitch links the 1/rev vibration level can be reduced in most cases far below the levels accepted today from the fixed RT&B compromise settings which stay unchanged throughout the whole flight envelope; 3. Optimum 1/rev vibration levels at different flight conditions cannot be achieved with a fixed set of pitch link lengths; the capability of an in-flight adjustment is crucial to achieve this goal; 4. Flat track is not a necessary or useful (pre)condition anymore to achieve minimum 1/rev vibrations; 5. The proposed In-Flight Tuning system is able to compensate for slowly increasing 1/rev vibrations resulting from external factors as water ingress, erosion or the like during operation of the aircraft. Hence, the number of dedicated RT&B procedures/flights can be reduced and the vibration level be kept at a low level. 6. The number of repetitive check flights with manual adjustments between the flights as used in today's RT&B procedures can be reduced to a single flight due to the in-flight adjustment functionality. The final prove of concept shall be achieved by the upcoming flight test campaign. Smart Pitch Rods will be fitted to a CH-53G helicopter and allow to validate not only the expected benefits but also to explore important operational aspects.


    Zugriff

    Zugriff über TIB

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    In-flight tuning: Wind tunnel test results and flight test preparation


    Weitere Titelangaben:

    Abstimmung während des Fluges: Windkanal-Versuchsergebnisse und Flugversuchsvorbereitungen


    Beteiligte:
    Fuerst, Daniel (Autor:in) / Arnold, Uwe T.P. (Autor:in) / Graham, Douglas (Autor:in)


    Erscheinungsdatum :

    2011


    Format / Umfang :

    12 Seiten, 22 Bilder, 1 Tabelle, 9 Quellen



    Medientyp :

    Aufsatz (Konferenz)


    Format :

    Print


    Sprache :

    Englisch




    In-Flight Tuning: Wind Tunnel Test Results and Flight Test Preparation

    Arnold, U.T.P. / Fuerst, D. / Graham, D. et al. | British Library Conference Proceedings | 2011


    CORRELATION OF WIND TUNNEL AND FLIGHT TEST RESULTS

    Symington, W. W. | SAE Technical Papers | 1940


    Experimental Results of Flight Test Based Gain Tuning

    Steinert, Agnes / Steffensen, Rasmus / Gierszewski, Daniel et al. | AIAA | 2022


    Wind tunnel & Flight Test of VCCS Morphing UAV

    Jeong, Jaebaek / Bae, Jae-Sung | IEEE | 2022