Zusammenfassung To minimize friction in the piston group of an internal combustion engine, systematic experimental testing must be performed on a number of design variants. A vehicle simulation can be used to determine fuel and CO2 savings of each variant in a driving cycle. Despite the transient operating conditions of the driving cycles, the analysis often uses friction maps measured in steady-state operation. This article therefore investigates whether a dynamic friction behavior occurs in transient engine operation. For this purpose, specific friction measurements with defined changes in operating point are taken. It appears that after changes in engine speed or load, both increases and decreases of friction can occur temporarily in comparison with measurements in steady-state operating conditions. The sign and magnitude of these differences depend on the specific change in operating point and on the engine temperature. The observed dynamic friction effects are characterized qualitatively and explanations of the underlying mechanisms are derived. Because the dynamic friction behavior can lead to a momentary difference of 15 % compared to the stationary friction value, friction measurements in transient engine operation appear to be sensible for evaluating savings potential in a driving cycle. It can be experimentally demonstrated, however, that dynamic friction phenomena have only a relatively low influence on cumulative fuel consumption and CO2 emissions.


    Zugriff

    Zugriff prüfen

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    Dynamic friction behavior of a gasoline engine in transient operation


    Beteiligte:
    Funk, Tobias (Autor:in) / Ehnis, Holger (Autor:in) / Künzel, Reiner (Autor:in) / Bargende, Michael (Autor:in)


    Erscheinungsdatum :

    2019-01-01


    Format / Umfang :

    17 pages





    Medientyp :

    Aufsatz/Kapitel (Buch)


    Format :

    Elektronische Ressource


    Sprache :

    Deutsch




    Dynamic friction behavior of a gasoline engine in transient operation

    Funk, Tobias / Ehnis, H. / Kiinzel, R. et al. | TIBKAT | 2019


    Simulation of a Small Turbocharged Gasoline Engine in Transient Operation

    Macek, Jan / Navrátil, Jiří / Polášek, Miloš | SAE Technical Papers | 2004


    Simulation of a small turbocharged gasoline engine in transient operation

    navratil,J. / Macek,J. / Polasek,M. et al. | Kraftfahrwesen | 2004


    Simulation of a Small Turbocharged Gasoline Engine in Transient Operation

    Navratil, J. / Polasek, M. / Society of Automotive Engineers | British Library Conference Proceedings | 2004


    Instantaneous friction components model for transient engine operation

    Zweiri, Y. H. / Whidborne, J. F. / Seneviratne, L. D. | SAGE Publications | 2000