This paper proposes a signal-based fault detection and isolation (FDI) system for heavy haul wagons considering the special requirements of low cost and robustness. The sensor network of the proposed system consists of just two accelerometers mounted on the front left and rear right of the carbody. Seven fault indicators (FIs) are proposed based on the cross-correlation analyses of the sensor-collected acceleration signals. Bolster spring fault conditions are focused on in this paper, including two different levels (small faults and moderate faults) and two locations (faults in the left and right bolster springs of the first bogie). A fully detailed dynamic model of a typical 40t axle load heavy haul wagon is developed to evaluate the deterioration of dynamic behaviour under proposed fault conditions and demonstrate the detectability of the proposed FDI method. Even though the fault conditions considered in this paper did not deteriorate the wagon dynamic behaviour dramatically, the proposed FIs show great sensitivity to the bolster spring faults. The most effective and efficient FIs are chosen for fault detection and classification. Analysis results indicate that it is possible to detect changes in bolster stiffness of ±25% and identify the fault location.


    Zugriff

    Zugriff über TIB

    Verfügbarkeit in meiner Bibliothek prüfen

    Bestellung bei Subito €


    Exportieren, teilen und zitieren



    Titel :

    A signal-based fault detection and classification method for heavy haul wagons



    Erschienen in:

    Erscheinungsdatum :

    2017




    Medientyp :

    Aufsatz (Zeitschrift)


    Format :

    Print


    Sprache :

    Englisch



    Klassifikation :

    BKL:    55.20 / 50.32 / 50.32 Dynamik, Schwingungslehre / 55.20 Straßenfahrzeugtechnik
    Lokalklassifikation TIB:    535/7020



    A signal-based fault detection and classification method for heavy haul wagons

    Li, Chunsheng / Luo, Shihui / Cole, Colin et al. | Taylor & Francis Verlag | 2017


    Bolster spring fault detection strategy for heavy haul wagons

    Li, Chunsheng / Luo, Shihui / Cole, Colin et al. | Taylor & Francis Verlag | 2018


    Curving Performance of Heavy-Haul Freight Wagons under Asymmetric Brake Shoe

    Zhang, Kailong / Liu, Pengfei / Cao, Yungiang et al. | TIBKAT | 2021


    Curving Performance of Heavy-Haul Freight Wagons under Asymmetric Brake Shoe Pressures

    Zhang, Kailong / Liu, Pengfei / Cao, Yunqiang et al. | ASCE | 2020


    Non-Metallic Components for Freight Wagons and Bogies - Experiences in North American Heavy Haul Service

    Rhen, D. L. / International Heavy Haul Association | British Library Conference Proceedings | 1997